EMERGENCY PHONE NO.: CHEMTREC (FOR SPILL, LEAK, FIRE, EXPOSURE OR ACCIDENT): 1-800-424-9300 (DAY OR NIGHT)

* * * * * * * * * * * * * * * * * M-415 * * * * * * * * * * * * * * *

PRODUCT DESCRIPTION: USDA and FDA acceptable proprietary blend of corrosion inhibitors.

Carcinogenic: OSHA = no NTP = no IARC = no

COLOR: Clear light yellow PHYSICAL FORM: Liquid

NON-VOLATILE (weight): N.A. ODOR: Amine

FREEZING POINT: N.E. BOILING RANGE: N.E.

pH: 9-11 (1% solution) EVAPORATION RATE: N.E.

MELTING RANGE: N.A.

density: 7.5-7.7 lb/gal (0.90-0.92 kg/l)

HMIS FLAMMABILITY RATING: 1

FLASH POINT: 219ºF (104° C)

FLAMMABLE LIMITS: LEL: N.E. UEL: N.E.

EXTINGUISHING MEDIA: Water, carbon dioxide or other dry chemical fire fighting agents.

UNUSUAL FIRE AND EXPLOSION HAZARDS: None.

SPECIAL FIRE FIGHTING PROCEDURES: Firefighters should wear self-contained breathing apparatus.

EMERGENCY AND FIRST AID PROCEDURES:

Eye Contact: Flush eyes with large amounts of water for 15 minutes. Consult a physician immediately. Skin Contact: Flush affected area for 15 minutes. If irritation persists, consult a physician. Cover the affected area with a sterile dressing and transport for medical care. Inhalation: Remove to uncontaminated area, administer oxygen if necessary. If victim has stopped breathing begin CPR. Get medical attention. Ingestion: If swallowed, give water or milk. DO NOT INDUCE VOMITING. Get immediate medical attention.

MEDICAL CONDITIONS PRONE TO AGGRAVATION BY

EXPOSURE: None known

PRIMARY ROUTES OF ENTRY: Inhalation, skin and eye contact.

HEALTH HAZARDS (acute and chronic) / EFFECTS OF OVEREXPOSURE:

STABILITY: Stable

HAZARDOUS POLYMERIZATION: Will not occur.

HAZARDOUS DECOMPOSITION PRODUCTS: Oxides of carbon and nitrogen.

INCOMPATIBILITY: Strong acids, alkalis, oxidizing agents, flames, and heat.

CONDITIONS TO AVOID: Contact with incompatible materials.

STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED: SMALL SPILL: Absorb on sweeping compound or other absorbent material. LARGE SPILL: Eliminate all ignition sources. All persons not wearing protective equipment should be excluded from area of spill until clean up has been completed. Stop spill at source. Dike area of spill to prevent spreading and pump liquid to salvage tank. Remove remaining liquid on sand, clay, earth, floor absorbent, or other absorbent material and place in containers.

WASTE DISPOSAL: Dispose of in accordance with applicable regulations.

HANDLING: Ground containers during transfer. Avoid shock or container damage. Remove all equipment that may be a source of ignition. Do not smoke, eat or drink in area. RESPIRATORY PROTECTION: A NIOSH approved respirator to remove vapors or mists.

PROTECTIVE GLOVES: Chemical resistant rubber or plastic.

EYE PROTECTION: Safety glasses/splash goggles.

OTHER PROTECTIVE EQUIPMENT: Eye wash station.

PRECAUTIONS TO BE TAKEN IN HANDLING: Avoid contact with skin and eyes. Avoid inhalation of vapors.

PRECAUTIONS TO BE TAKEN IN STORING: Completely drain "Empty" drums, properly bung and promptly dispose in an environmentally safe manner and in accordance with governmental regulations. Recycle drums only through qualified reprocessing organizations.

T.S.C.A. STATUS: Listed

U.N. NUMBER: 2565

DOT/IATA SHIPPING NAME: Dicyclohexylamine

DOT/IATA HAZARD CLASS: 8, Pg. III

DOT/IATA REQUIRED LABELS: Corrosive

TECHNICAL SHIPPING NAME: N.A.

IMDG: 8160, Amdt. 28-96

FREIGHT CLASS BULK: Same as above

LTL: 55 TL: 35 MW: 40

PREPARED BY: Margarita Kharshan, R&D Manager

APPROVED BY: Boris Miksic, President/CEO

DATE PREPARED: 4/15/99 SUPERSEDES: 8/3/98

DISCLAIMER: This information is furnished without warranty, expressed or implied, except that it is accurate to the best knowledge of the Cortec Corporation. The data on this sheet relates only to the specific material designated herein. The Cortec Corporation assumes no legal responsibility for use or reliance upon this data.

N.E. = NOT ESTABLISHED N.A. = NOT APPLICABLE